Expert Nissan DPF cleaning
The diesel particulate filter on your Nissan — fitted with the YD25/YS23 dCi diesel engine — captures soot from the exhaust and burns it off during regeneration. Nissan Navara DPFs are a frequent cleaning job after heavy stop-start use. When the filter blocks, you'll often see a warning light, lose power, use more fuel, or drop into limp mode.
Rather than replacing an expensive factory part, our off-car cleaning process removes the trapped soot and ash and restores your Nissan DPF to near-original flow — for a fraction of the cost.
Common signs on your Nissan
Nissan's YD25 and YS23 diesel engines in the Navara and X-Trail are dependable, but tradie-style stop-start use with a loaded tray is one of the most common reasons we see these filters arrive heavily blocked with both soot and ash.
A blocked filter on this engine family can trigger fault codes such as P2002, P244B — both indicate the DPF needs attention rather than a new part.
Nissan models we service
We clean DPFs across the Nissan diesel range, including popular models such as Navara, Pathfinder, X-Trail dCi, as well as other Nissan diesels. Not sure if yours qualifies? Just call us.
Why clean instead of replace?
- ✓ Save thousands — a new Nissan DPF costs $3,000–$7,000 fitted
- ✓ Same-day turnaround — usually 3 to 4 hours
- ✓ Flow-tested before and after, so you see the result
- ✓ Australia-wide by post if you're outside Sydney
Our process
- Diagnose and remove the Nissan DPF
- Initial flow test to measure the blockage
- Deep clean to remove soot and ash
- Second flow test to confirm the result
- Refit, clear fault codes and road test